AmazingRibs.com is supported by our Pitmaster Club. Also, when you buy with links on our site we may earn a finder’s fee. Click to see how we test and review products.

Char-Griller Duo Model 5050 Combo Gas and Charcoal Grill Review

Share on:
Char-Griller Duo Model 5050

This is a great concept, a capacious gas and charcoal grill in one unit, and you can add an optional offset charcoal firebox to make it a smoker, too. Unfortunately the quality is reflected in their price. Cheap.

The gas side on the left produces 40,800 BTU with 3 burners. A side burner puts out 12,000 BTU. There is no natural gas optional hookup. We recently tested the stand alone version of the gas side called “Grillin’ Pro” and were pleasantly surprised by its searing performance. Click here for our Grillin” Pro Review.

The barrel on the right is a charcoal grill. Each barrel has a primary cooking surface of 438 square inches for a total of 876 square inches. It has an adjustable charcoal grate, though it’s not well-designed: the grate, which is of narrow-gauge steel, has a handle on left and right that is connected by eye-hooks. That means that when you raise or lower it, it can swing left and right; it also means that to do that, you have to lean over the grill somewhat.

There is a single, battery powered ignitor, porcelain-enameled cast iron grates, a 5-year burner warranty, and a 1-year warranty on all other parts. On the left of the grill is a shelf with a trap door, under which is the electronic ignition for the gas grill. The shelf converts into a side gas burner, too. It has hooks for utensils on the side shelf, which is handy.

But the metal is thin, the lids don’t seal, the thermometers are cheap and useless, some handles are plastic, the side shelves are small, and the warming racks can’t be removed. One buyer on Amazon wrote “When the lids are open, the warming racks go up/back right over the lid. Anything that drips off the warming rack goes right down the lid and onto the ground behind the grill. I found this out the hard way after an afternoon of cooking burgers. What a mess! There are no bumpers around the grilling perimeter. One bad spatula or tong move and your meat will slide right off in any direction! They should have at least put a bumper in the back. The joints aren’t tight. Any grease that drips down on the propane side in the corners between the bottom and side pieces of the grill goes right between the two pieces of metal and drips on the propane tank.” There are complaints about the grates themselves: it’s been reported that the porcelain coating pops off. Char-Griller replaced the gates in that case.

The price is right for do-it-yourselfers who like to modify their cookers. One popular mod is to use the charcoal tray from the optional firebox as a heat diffuser on the left gas grill, where some have used other means such as a soapstone slab or “tuning plates” that can be moved from right to left a couple inches each to distribute the heat more toward one area or another. Some people have inserted gaskets to improve the seals to produce more even airflow, or have added a metal duct hose inside to bring the exhaust pipe closer to the grates, important on a windy day when it would ordinarily lose a lot of heat. Others have put water heater blankets on them for insulation, which is not expensive.

For the tinker with a tight budget, the Char-Griller Duo can be a BBQ bounty of weekend projects. But for the cook who strives for great outdoor meals, it leaves a lot to be desired.

Special thanks to Scot Murphy for his input on this review.

Haven't found what you want?
Click the buttons below to search our complete database of reviews:

Product Information:

  • Model:
    Duo Model 5050 Combo Gas and Charcoal Grill
  • Item Price:
    $ 299.00
    *Price Subject To Change
  • Where to buy (buying from this supplier supports this website):
  • Made in USA:
    no
  • Review Method:
    Looked Closely At It
    We have seen this product up close and we have also gathered info from the manufacturer, owners, and other reliable sources.
  • Primary Function:
    Grill, Combination Grill and Smoker
  • Burner Type:
    Side
  • Fuel:
    Charcoal, Propane Gas, More Than One Fuel
  • BTU:
    40,800
  • Heat Flux:
    46.58
    Heat Flux is the BTU per square inch and is a more useful measure of how much heat a grill delivers than BTU alone.
  • Main Burners:
    3
  • Primary Capacity:
    876 square inches
    Large (about 43 burgers)
  • Secondary Capacity:
    384 square inches

Published On: 12/3/2012 Last Modified: 3/6/2021

  • Max Good, Full time grill tester - Max Good, AmazingRibs.com's Vice President of Product Reviews & Keeper of the Flame, is the man in charge of finding the best products for the AmazingRibs.com Equipment Reviews section. Max bottles his own barbecue sauce recipes and now sells them around the country.

 

High quality websites are expensive to run. If you help us, we’ll pay you back bigtime with an ad-free experience and a lot of freebies!

Millions come to AmazingRibs.com every month for high quality tested recipes, tips on technique, science, mythbusting, product reviews, and inspiration. But it is expensive to run a website with more than 2,000 pages and we don’t have a big corporate partner to subsidize us.

Our most important source of sustenance is people who join our Pitmaster Club. But please don’t think of it as a donation. Members get MANY great benefits. We block all third-party ads, we give members free ebooks, magazines, interviews, webinars, more recipes, a monthly sweepstakes with prizes worth up to $2,000, discounts on products, and best of all a community of like-minded cooks free of flame wars. Click below to see all the benefits, take a free 30 day trial, and help keep this site alive.


Post comments and questions below

grouchy?

1) Please try the search box at the top of every page before you ask for help.

2) Try to post your question to the appropriate page.

3) Tell us everything we need to know to help such as the type of cooker and thermometer. Dial thermometers are often off by as much as 50°F so if you are not using a good digital thermometer we probably can’t help you with time and temp questions. Please read this article about thermometers.

4) If you are a member of the Pitmaster Club, your comments login is probably different.

5) Posts with links in them may not appear immediately.

Moderators

  Max

Click to comment or ask a question...

Spotlight

These are not paid ads, they are a curated selection of products we love.

All of the products below have been tested and are highly recommended. Click here to read more about our review process.

Use Our Links To Help Keep Us Alive

Many merchants pay us a small referral fee when you click our “buy now” links. This has zero impact on the price you pay but helps support the site.