"I try not to be a jerk. I really do. I try to be nice and cordial."Mariah Carey
Jerky is a fun snack, but it is far more versatile than you might imagine. Like BLT sammies? Bench the bacon and play the jerky. Like bacon in your salad? Jerk it and replace it. Many of things bacon can do, jerky can do too, often better! Think of homemade jerky as lowfat bacon.
And it is a lot healthier than you think. Start by looking at the ingredient list of a bag of jerky in the store. Now look at the ingredient list below.
Jerky is dried meat that retains much of the nutritional value of fresh meat but weighs less than half and takes up a lot less space. USDA calls it "nutrient dense." We eat it as a treat nowadays, but in the days before refrigeration, it was once an important source of protein.
Marinated Beef Jerky Recipe
Before you get started, I recommend you read my article on dried foods.
Jerky is dried meat that retains much of the nutritional value of fresh meat but weighs less than half and takes up a lot less space.
Makes. About 1 1/2 pounds
Preparation time. 45 minutes
Marination time. 12 to 24 hours
Cooking time. 2 hours
Drying time. 6 to 12 hours depending on how thick you sliced the meat.
2 to 3 pounds eye of round beef
1 cup soy sauce
1/2 cup molasses, honey, or sorghum
1/4 cup Bourbon, Scotch, dark rum, brandy, or other dark whiskey
5 tablespoons fresh ginger, peeled and grated on a box grater
3 tablespoons Kansas City style (sweet tomato based) barbecue sauce
3 tablespoons Meathead's Memphis Dust
1 tablespoon hot sauce
About the beef. Since fat will not dehydrate and it gets funky with age, the best meats are lean muscles that are well trimmed. I recommend eye of round, top round, or bottom round. I am told that or flank steak and lean brisket from the flat section are also good, but I have not used them. Do not use ground beef. Pick something that is on sale. This is also a great use for hunks of meat that have been in the freezer a long time. When they defrost they tend to give up a lot of moisture and are therefore less desirable than fresh meat. Jerky is a great use for them.
Other meats. Turkey breasts are good for making jerky. Rabbit loin and lean cuts from venison, elk, antelope, deer, caribou, moose, and buffalo also work very well. Bear is too greasy my hunter friends say. The Oregon State University Extension Service says game meats should be frozen for at least 60 days at 0°F to kill parasites.
About the soy sauce. Soy sauce is the salt source in this recipe and it is important as a microbial inhibitor. Make sure it is more than half the contents of your marinade. Get a good fermented soy sauce like Kikkoman.
About the ginger. Please DO NOT skimp on the ginger and DO NOT substitute ginger powder. It really ads to this recipe.
About the booze. None of the alcohol will remain in the meat after drying. Alcohol evaporates at a lower temp than water. But it does add oaky flavor, especially if you dry the meat indoors or without smoke. The alcohol helps pull moisture from the meat, however, and this is good.
Optional. If you can't smoke it, you might want to add 1 tablespoon of liquid smoke. Worcestershire is another popular addition.
1) Slicing the meat. Put the meat in the freezer for an hour or two to stiffen it and make it easier to cut. Cut the meat in disks about 1/8 to 1/4" thick. Strive to make them uniform in thickness. You don't want them paper thin because they will shrink in in half, but you don't want it too thick or it will take forever to dry. I like to cut across the grain to make it less chewy. Some folks cut with the grain to give their mandibles more of a workout. They won't be long strips like bacon. Odd shapes are good. They tell people that it is home made. Put the meat a 1 gallon zipper bag.
2) Marinating. Mix the marinade by whisking all the ingredients together. Pour it into the zipper bag. Put the bag in a bowl or pan in the refrigerator to catch any leaks. Let the marinade make love to the meat all night long at least. Occasionally pick up the bag and roll it around massaging it for several minutes to make sure the liquid is contacting all the meat surfaces. This is important. It can stay in the marinade for up to 2 days if you wish. When you are ready to cook, drain the meat in a colander and discard the marinade. Do not save it for another day.
3) Cooking, smoking, and killing the bugs. Jerky elitists don't like the idea of cooking the meat, but it is absolutely necessary to make the meat safe if you are not using a preservative and even then, cold smoking is risky and I cannot recommend it for home cooks. Smoke is not necessary, but it adds a pleasing BBQ flavor and improves shelf life in the fridge. A good digital oven thermometer is important for this phase unless you've been hankering to get up close and personal with Salmonella, E. coli O157:H7, and Listeria monocytogenes. You cannot trust your grill's bi-metal dial thermometer. It can be off by as much as 50°F. Click here for the USDA guidelines for commercial jerky production.
Set up your grill for 2-zone indirect cooking shooting for about 200°F in the indirect zone. Get that wood right on the heat source to make sure it smokes. On a gas grill you will want to put it in an aluminum foil packet and poke holes in it. If you wish, you can prop open the lid of your cooker to let heat escape in order to keep the cooking temp down. This will also increase air flow. If you normally use a water pan, skip it today. The goal is dehydration not moisturizing.
Spread the meat on a grill grate or a grill topper. I am a big fan of the non-stick narrow mesh Frogmats for the job, especially since they can be cleaned in the dishwasher. Make sure the meat is not folded over on itself or overlapping. You can use both lower and upper grates if your setup allows. Smoke for about 15 to 60 minutes. That'll kill the bugs and add smoke flavor. If you are using a grill and the heat is on one side, then you may need to rotate the meat so the stuff on the cooler side goes to the hot side after about 30 minutes. This will get the center of the meat up past the kill zone and start the dehydration.
4) Drying. The final step is dehydration. You can stop smoking and cooking and dry the meat to jerky consistency. That means dark, almost black, but not carbonized, pliable but breakable, but not so brittle that it shatters. Drop the cooker's air temp to no lower than 140°F and hold it there. If you have an indoor kitchen dehydrator, you can move the meat there at this stage. They are great because they have a fan and that can reduce drying time to less than 6 hours. I have an article about electric dehydrators here. Or you can put it in your oven, just leave the door cracked open a bit. Drying on a grill or in the oven can take as long as 12 to 18 hours depending on the temp and how thick the meat is. It is hard to get a grill or smoker or even indoor oven down to 140°F, so just get as low as you can. If you need to, you can leave the lid or door partially open to dissipate the heat. The hotter it is the crunchier the meat will get, but you want a balance between crunchy and chewy. You want jerky, not hard candy.
During the process, the meat will start out tan in color, progress through rosy, and eventually blacken. But it is not really black. It is just really really dark. You want to remove it right after the last bit of rose color disappears. But that's my preference. It will also lose about half it's weight. As it starts to go, start tasting. Learn what texture you like best. This might require a lot of tasting. And beer. And friends to offer their opinions. The drier it gets, the longer it keeps. How long? If you have been careful about cleanliness and hit the temperature guidelines above (this is especially important for game), USDA says it can be stored safely a month or two at room temp. I use a vacuum sealer and keep mine in the fridge just to be sure. And yes, it can be frozen.
Nobody knows how long man has been making jerky, but it has probably been around since soon after man started eating meat since it kept for days or weeks without refrigeration. It became famous in the US as cowboy food for long cattle drives. Cowboys could pack it in saddle bags and snack on it while mounted. It was lunch.
According to the historians jerky has been around since since ancient Egypt. Early hunter-gatherers and nomadic tribes made jerky from animals that were too big to eat all at once. It was probably just thin strips of sun dried meat. Soaking in salt water before drying was probably an early innovation since salt helped fite off bacteria and helped it keep longer. It probably didn't take long for to discover that smoking it made it taste better and the properties of the smoke helped it keep longer still.
The concept has many forms. Biltong is dried meat popular in many African countries. Amerindians ground dried meat and dried fruit to make pemmican. The word "jerky" is believed to have come from the Spanish word charque which means roughly "dried meat."
Over the years the process has been reinvented to improve safety, shelf life, and flavor. Most storebought jerky is dry and leathery because it is salt cured, chemically preserved, smoked or treated with liquid smoke, and processed to meet USDA standards for storage at room temp. Homemade jerky, properly made, can be better tasting, and probably better for you. Let's look at the different methods of making jerky.
Dry cured. This is the true, classic, traditional cowboy jerky, and jerky elitists and survivalists will tolerate no other approach. When done properly, it is tasty, salty, has a shelf life of a year or more at room temp in the bomb shelter, and it is home on the range or in backpacks. This method is best reserved for commercial producers because the meat is not cooked and can harbor pathogens if not handled properly. Here's a rough overview of the process, although there are many variations: Thin slices of meat are packed on all sides with a mix of salt, sugar, spices. The meat is refrigerated for at least two days, and then it is cold smoked and dehydrated at low temps for days. Many folks consider this method risky, and they use a commercial product called Morton's Tender Quick as a preservative. It contains salt, sugar, sodium nitrate and sodium nitrite as curing agents, and propylene glycol to keep the mixture uniform.
Wet cured. Considered a shortcut by some elitists, the meat is sliced and soaked in a concentrated salty brine that has been flavored with spices and a sweetener like sugar, molasses, or honey. Liquid smoke is a common addition. The meat is then removed and dried in a cold smoker, dehydrator, or oven. Tender Quick can also be used. This is the method preferred by commercial producers.
Marinated. My favorite method is easy, safe, and more flavorful. It is a lot like wet cured, only the salt concentration is lower, the flavorings are more intense, and there are no preservatives. Although these jerkies must be refrigerated for long term storage they can be taken out long enough to accompany you to the game, concert, or camping trip. The recipe below has a lot of flexibility, but I recommend you stick close to my plan the first time out. Then riff away.