AmazingRibs.com is supported by our Pitmaster Club. Also, when you buy with links on our site we may earn a finder’s fee. Click to see how we test and review products.

You Have Stumbled Across The Ultimate Double Smoked Ham Recipe

Share on:
double smoked ham

Smoked Ham Is Good But Double Smoked Ham Is Better! Here’s The Recipe And Video To Get It Done

Holidays at my house wouldn’t be the same without a ham. But while store bought ham (either whole or spiral) is fine, this recipe for double smoked ham on the grill is a whole other level of flavor. While it’s true that smoking a precooked ham may seem like overkill but the depth of flavor it produces is worth the effort!

The problem with most wet-cured hams is that they are dry when you cook them according to the instructions on the package, and the smoke flavor is barely noticeable. So when preparing our double smoked ham, we’ll cook it a lot lower and slower to keep the moisture in, add just a little fresh smoke, wrap it in foil to hold in moisture, sizzle on a glaze, and make a thin sauce that will penetrate the meat and add back moisture.

Once double smoked, you can use the glaze that is packed in with the ham, but I chuck it and use a ham glaze recipe from the great pitmaster, Chris Lilly, executive chef at Big Bob Gibson’s in Decatur, AL, and author of Big Bob Gibson’s BBQ Book: Recipes and Secrets from a Legendary Barbecue Joint. It is a balanced blend of sweet and savory with apricot preserves, honey, brown sugar, mustard, Worcestershire, soy sauce, as well as herbs and spices. There’s a link to the recipe below.

Big Bob Gibsons BBQ Book

Flying Pigs Ain’t Got Nuthin’ On This Double Smoked Ham! (click here to share this on Twitter).

Remember to save the bone for split pea soup, and if you play it right, there will be leftover ham and that means sandwiches with South Carolina Mustard Sauce, fritatta, Hoppin John beans, eggs Benedict, Hawaiian pizza, ham salad…

Selecting the right ham

The world of hams is confusing, and that’s an understatement, but it is worth getting a handle on things because a little knowledge will make your ham dinners much much better.

Hams are cut from the top of the rear legs of hogs, from the knee to the hip, including the big meaty rump muscles, and they can be divided into four broad categories: Fresh hams, dry cured hams, wet cured hams, and injected hams. Alas, when you buy a ham, it most often is labeled something else, like Boiled Ham, Canned Ham, Ibérico Ham, Picnic Ham, Prosciutto, Smithfield Ham, Smoked Ham, Spiral Cut Ham, and Virginia Ham to name a few.

By far the most popular hams in the US are wet-cured hams, hams that have been injected with a brine and then pre-cooked. The brine usually has salt, sugar, and spice and lots of stuff nice, and the cooking often includes smoking. This was a method developed for preserving large hunks of meat like hog rumps long before refrigeration was invented.

Wet-cured hams are pinkish purple in color, often have a sweet glaze baked on, and are frequently put on a lathe where a blade can spiral cut them while they are turned. This makes carving them at the table a snap during Easter and other holidays. They usually come in a plastic shrink wrap, and if it says “cooked” on the package, you can eat it cold right out of the bag. But cured hams are better served warm with a sweet glaze to counterbalance the saltiness from the brine that was injected into it.

Since wet cured hams are precooked, in theory all you need to do is warm yours throughout, avoid high heat, and avoid cooking too long to keep it from drying. Standard cooking technique on the package and in all the cookbooks says to heat it at 325°F (162.8°C) until it reaches 140°F (60°C) . But that is a “how to” for dry meat. If you take a little care you can really amp yours up to 11 on the grill (although the same method works fine indoors).

If your head is starting to spin, my article, The Science Of Ham, explains almost all the different types of ham, and it is worth a read if you ever hope to become a master hamster. First of all, try to find one that has been trimmed properly. You don’t want skin or a thick fat layer. Nobody will eat them, and they don’t add moisture or any flavor to the meat, so it is waste. You want the smoke and the glaze on the meat, not on the skin or fat. Now on to our double smoked ham recipe!

Up your game: Join our Pitmaster Club. Try it out for free for 30 days. No credit card is needed. No spam. Join now and Be Amazing!

The Ultimate Smoked Ham Recipe And Video


double smoked ham
Tried this recipe?Tell others what you thought of it and give it a star rating below.
4.61 from 254 votes
Anyone can serve boring store-bought ham but those "in the know" hit the smoker or grill to take it to a whole other level of smoky deliciousness!

Serve with: Grilled asparagus and grilled sweet potato steak fries. To Drink: A slightly sweet rosé is traditional, and with good reason. A hint of sweetness pairs with the glaze and balances the saltiness. Among my other faves are rieslings in the 1 or 2% sweetness range from the Finger Lakes, Pacific Northwest, or German and Austrian Kabinetts.


Course:
Dinner
,
Lunch
,
Main Course
Cuisine:
American

Makes:

About 6 1/2 pounds (2.9 kg) meat
Servings: 12

Takes:

Prep Time: 10 minutes
Cook Time: 2 hours 30 minutes
Total Time: 2 hours 40 minutes

Ingredients

Metric conversion:

These recipes were created in US Customary measurements and the conversion to metric is being done by calculations. They should be accurate, but it is possible there could be an error. If you find one, please let us know in the comments at the bottom of the page

Method

  • Prep. You can do this step well in advance. Make 1 cup (236.6 ml) of Chris Lilly's Spicy Apricot Glaze. Put the chicken broth in a pan and whisk in 4 tablespoons of the glaze over medium heat until it is dissolved. Put both the glaze and the broth in the fridge.
  • Fire up. Prepare your grill for 2-zone cooking and preheat it to about 225°F (107.2°C) on the indirect side. If the skin has not been removed, remove it, and trim off almost all the fat leaving no more than a thin layer. The fat does not penetrate the meat and people will just trim it off at the table and there goes your glaze. If it came with a prepackaged glaze, throw it out. If there is a glaze already on the meat, rinse it off. Chris' glaze is better. If it is spiral-sliced, let some water get into the sliced areas to help reduce moisture loss.
  • Cook. Place the meat on the indirect side of the grill flat side down, add a handful or two of wood for smoking as described in my articles on the Best Setup for a Charcoal Grill, the Best Setup for a Gas Grill, the Best Setup for a Bullet Smoker, and the Best Setup for an Offset Smoker. You do not need much smoke since the meat has been smoked once already. Close the lid, and smoke for about 30 minutes.
  • Tear off about 5' (1.5 m) of aluminum foil, if you have double strength, that's better. Fold it in half to make it about 2 1/2' (76.2 cm) in length. Take the ham off the grill, place the flat side on the foil making sure you don't puncture the foil with the bone, pour 1/2 of the broth/glaze mix over the meat and seal the meat and broth/glaze mix in the foil making it look like a giant candy kiss. Crimp the seams tight. We don't want any steam escaping or broth leaking. This technique helps it cook faster by generating a little steam, which penetrates faster than dry heat, and keeps the meat moist. If it is leaking, use another layer of foil or place it in a pan. Place it back on the indirect side at about 225°F (107.2°C). If you have a leave-in meat thermometer, insert it now through the foil into the fat end above the liquid level, so the tip is about 1" (2.5 cm) away from the bone. Watch the oven temp and try to keep it around 225°F (107.2°C).
  • When the meat temp hits about 130°F (54.4°C), open the foil, paint on the full strength glaze, leave the foil open to catch drips, close the grill, and roast for about 10 minutes until the glaze gets thick. How long will it take to hit 130°F (54.4°C)? That depends on the thickness of the meat and the accuracy of your oven thermometer. As I tend to repeat in every recipe, you cannot trust your grill thermometer no matter how much you spent on your grill, and you need a meat thermometer to tell when the meat is done. Please read my article on thermometers and take action.
  • Glaze the ham. After about 10 minutes, open the grill, dip your basting brush in the pools of broth/glaze on the foil and paint the meat again. Add more full strength glaze if you wish. Now remove the foil, and pour it into a sauce pan. That's the basis for your sauce. Taste it. Add more glaze or broth as you wish. The thinner it is the easier it soaks into the meat. Don't get too sweet. Keep it warm on the grill or indoors.
  • Leave the lid open, remove the thermometer and move the ham over to the hot side of the grill and lay it on a curved side so the glaze is facing the heat and the bare meat is not. Stand right there and watch so the glaze does not burn. Don't walk away even to get a beer. Let the glaze sizzle, but not blacken. You are just trying to caramelize the sugars and develop more flavor. After about 3 or 4 minutes, roll it a bit and keep rolling it until all sides have sizzled except the flat side. Leave it bare. By now the temp should have risen to 140°F (60°C). Go ahead and check if you want, but trust me, it's there.
  • Serve. Pour the sauce into a gravy boat for serving, and move the ham to a cutting board, flat side down. Carve it by slicing inward from the sides towards the bone parallel to the table top. Then slice down along the bone to release the slices. Serve, and spoon a little sauce over the meat. Here's great photo of a skin on ham by a reader Roman Matla.
    roman matla ham

Nutrition per Serving

Calories: 417kcal | Carbohydrates: 20g | Protein: 44g | Fat: 19g | Saturated Fat: 5g | Cholesterol: 166mg | Sodium: 2667mg | Potassium: 682mg | Fiber: 1g | Sugar: 17g | Vitamin A: 45IU | Vitamin C: 54mg | Calcium: 21mg | Iron: 3mg

Related articles

Published On: 12/4/2012 Last Modified: 5/21/2022

Share on:
  • Meathead - Founder and publisher of AmazingRibs.com, Meathead is known as the site's Hedonism Evangelist and BBQ Whisperer. He is also the author of the New York Times Best Seller "Meathead, The Science of Great Barbecue and Grilling", named one of the "100 Best Cookbooks of All Time" by Southern Living.

 

High quality websites are expensive to run. If you help us, we’ll pay you back bigtime with an ad-free experience and a lot of freebies!

Millions come to AmazingRibs.com every month for high quality tested recipes, tips on technique, science, mythbusting, product reviews, and inspiration. But it is expensive to run a website with more than 2,000 pages and we don’t have a big corporate partner to subsidize us.

Our most important source of sustenance is people who join our Pitmaster Club. But please don’t think of it as a donation. Members get MANY great benefits. We block all third-party ads, we give members free ebooks, magazines, interviews, webinars, more recipes, a monthly sweepstakes with prizes worth up to $2,000, discounts on products, and best of all a community of like-minded cooks free of flame wars. Click below to see all the benefits, take a free 30 day trial, and help keep this site alive.


Post comments and questions below

grouchy?

1) Please try the search box at the top of every page before you ask for help.

2) Try to post your question to the appropriate page.

3) Tell us everything we need to know to help such as the type of cooker and thermometer. Dial thermometers are often off by as much as 50°F so if you are not using a good digital thermometer we probably can’t help you with time and temp questions. Please read this article about thermometers.

4) If you are a member of the Pitmaster Club, your comments login is probably different.

5) Posts with links in them may not appear immediately.

Moderators

  Max

Click for comments...

Spotlight

These are not paid placements, they are a curated selection of reviewed products.

All of the products below have been tested and are highly recommended. Click here to read more about our review process.

Use Our Links To Help Keep Us Alive

Many merchants pay us a small referral fee when you click our links and purchase from them. This has zero impact on the price you pay, but has a major impact on our ability to maintain and improve this site so please click our “buy now” buttons on product reviews!


BBQ And Grilling Gifts For Every Occasion


Looking for the perfect gift for the BBQ and grilling enthusiasts in your life? Here’s our suggestion for platinum and gold medal-winning products at a variety of price points. Click here to see our list of Gold Medal Gifts.


GrillGrates Take Gas Grills To The Infrared Zone


GrillGrates amplify heat, prevent flare-ups, make flipping foods easier, kill hotspots, flip over to make a fine griddle, and can be easily moved from one grill to another. Click here for more about what makes these grates so special.


Bring The Heat With Broil King Signet’s Dual Tube Burners

3 burner gas grill

The Broil King Signet 320 is a modestly priced, 3-burner gas grill that packs a lot of value and power under the hood including dual-tube burners that are able to achieve high, searing temps that rival most comparatively priced gas grills. Click here to read our complete review.


The Pit Barrel Cooker May Be Too Easy


The PBC has a rabid cult following for good reason. It’s among the best bargains for a smoker in the world. This baby cooks circles around cheap offset smokers because temperature control is so much easier. Click here to read our detailed review and the raves from people who own them.